高压缸疏水管道超温爆破失效分析.pdfVIP

梁 军, 徐亚涛 神华国华( 北京) 电力研究院, 北京 100069 [ ] 通过对某发电公司300 MW 机组汽轮机高压缸疏水管道超温爆 的试验分析及理论计 算, 认为高压缸疏水管道的特殊结构形成超音速气流摩擦发热, 其发热效果远大于对流 换热效果, 是导致管道超温爆 的主要原因相关试验和计算理论为防止这种特殊结 构的管道爆 提供了依据 [ ] 300 MW 机组; 汽轮机; 高压缸;疏水管道; 超温;爆 + [ ] T K223. 1 1 [] B [ ] 1002- 3364(2009)08- 0129- 04 [DOI ] 10.3969/j.issn. 1002- 3364. 2009.08. 129 FAILURE ANALYSIS OF OVER TEMPERATURE BURST ON DRAIN PIPELINE FROM HIGH PRESSURE CYLINDER LIAN Jun,XU Ya- tao Shenhua uohua ( Beijing) Electric Power Research Institute, Beijing 100069, PRC Abstract:T hrough test analysis and theoritical calculation for over- temperature burst of drain pipeline from high- pressure (HP) cylinder of the steam turbine for 300 MW unit in one Power eneration Co Ltd,the causes leading to a special phenomenon, i. e. the severe over- temperature burst occurred on the drain pipelineunder condition of the exhaust steam temperatrue from HP cylinder of the steam tur- bine was far lower than the service temperature of 12Cr1MoV steel used in the hydraulic pipeline, has been explained.T he effect of rubbing heat due to supersonic steam flow resulted from special structure of the drain pipeline from HP cylinder is far larger than the effect of convective heat exchange,finally resulting in over- temperature burst of the pipeline. T he related tests and calculation theory provide basis for preventing this kind of pipeline burst due to its special structure. Key ords:300 MW unit; steam turbine;HP cylinder;hydraulic pipeline;over- temperature;burst 3 300 MW 491 e , 11. 975 MPa; 380 e ,5. 675 MPa, ,,