甾醇提取过程中回收甘油方法及工艺条件的研究-吉林农业大学学报.PDF

吉林农业大学学报 2005, 27(3) : 319~ 322 Journal of Jilin Agricultural University * 1 2 1** 2 1 2 李晓丽 , 陈 星 , 刘景华 , 刘 蕾 , 魏丽丹, 邱炳源 ( 1. 吉林农业大学资源与环境学院, 长春 130118; 21 国家大豆深加工研究与推广中心, 长春 130022) : 根据甾醇 取工艺的特点, 建立了废水处理的工艺流程, 并对其试验条件进行优化活性炭脱色的 最佳条件: 粉末状活性炭用量为21 0% , 反应温度为80e , 反应时间20 min此工艺硫酸钠的收率为 80% ~ 85% , 经离子交换脱盐, 真空浓缩后甘油含量8913% , 甘油的回收率8911% 该工艺处理后的水可以再利用 : 甾醇; 甘油; 活性炭脱色; 离子交换 : X703 : A : 1000-5684( 2005)03-0319-04 Studies on New Ways of Recycling Glycerin in Extracting Phytosterol 1 2 1 2 1 2 LI Xiao-li , CH N Xing , LIU Jing-hua , LIU Lei , W I L-i dan , QIU Bing-yuan ( 1. College of Resources and Environment , Jilin Agricultural University , Changchun 130118, China ; 2.National Research and Pop ulari ation Center of Soybean Rfe ined Processing , Changchun 130022, China) Abstract: According to the characters of phytosterol extracting processing, a new way of treating waste water was constructed1 The best conditions for decolorizing with activated carbon were found. Amount of dusty active carbon is 210%, decolorizing temperature is 80e , and time of decolorizing is 20min1 Acti- vated carbon has almost no effect on the glycerin content1Recycle rate of sodium sulfate techniques was 80% ~ 85% .It can decide how much activated carbon could be used1The glycerin content of product was 8913% and the rate of recycling glycerinwas 8911% after the treatment of desalting and vacuum concen- trating1 Key words: ion exchange; phytosterol; glycerin; decolorizing of activated carbon