三相生物流化床处理淀粉废水工艺研究-化学工艺专业论文.docx

40。C，COD。，去除率可达90％以上。厌氧出水经--tl|生物流化床处理后COD。， 40。C，COD。，去除率可达90％以上。厌氧出水经--tl|生物流化床处理后COD。， 总的去除率为99％。实验结果表明用厌氧预处理一三相生物流化床来处理淀 粉废水在技术上是可行的。 关键词；三相生物流化床传质载体淀粉废水处理 Ⅱ TREATMENT TREATMENT OF WASTE、7l，ATER FRoM STARCH PRoDUCIoN BY THREE．PHASE BIoLoGICAL FLUIDIZED BED PRoCESS ABSTRACT Three-phase biological fluidized bed is a new biological treatment technology in wastewater treatment．It integrates conventional chemical engineering fluidized technique and immobilized microorganism．Characterized as laJ【911 loading and hi曲efficiency,it is regarded as one of the most prospective biological treatment technique in the field ofwater pollution contr01． A determination method on kLa in three-phase biological fluidized bed had founded firstly according to the experiment in this paper．The effects of screen mesh，volumetric gas rate and carrier quantity on kLa were investigated． The result showed that the maximum volumetric mass transfer coefficient of the reactor is 0．0508 S’1 and mass transfer efficiency(EA)is 22．06％． Then studied on the producing wastewater of starch treatment by three—phase biological fluidized bed．Through the formation of biofilm on biology carrier and based on the theory of immobilized microorganism， reseached the impacts of carrier partical diameter,carrier quantity,volumetric gas rate，hydraulic retention time et al on the producing wastewater of starch． The experimental results show that after the formation of biofilm and running 111 stably，the stably，the CODcr removal rate was 80％around when activated carbon quantity Was 10％(v／v)，and activated carbon partical diameter Was O．5mm～lmm，and volumetric gas rate was 1 00L／h,and hydraulic retention time was 90rain． Else this paper studied the starch wastewater treatment by anaerobic pretreatment一-three-phase biological fluidized bed．On the condition that the CODcr ofinflow was about 21000mg／L，the volume ofanaerobic granular sludge was IO％(V／V)，the initial pH Was about 7．5，the temperature Was 40。C，HRT of anaerobic W