脱硫经济运行研究.pdfVIP

2009.10 中国 昆明 2009 年清洁高效燃煤发电技术协作网年会 1 脱硫经济运行研究 陈泽彦，朱贵荣，黄小华 （大唐华银株洲发电有限公司，湖南株洲 412000 ） Study of Desulfurization System Economic Operation Chen Ze-yan , Zhu Gui-rong ，Huang Xiao-hua Datang Huayin Zhuzhou Power Generation Co.,Ltd. Zhuzhou, Hunan, 412000 摘 要：针对大唐华银株洲火力发电公司脱硫系统运行能耗高的现状进行分析研究，提出对球磨机循环泵变频 改造，提高制浆密度，提高制浆效率；对吸收塔密度计和 PH 计移位改造，便于对参数长期实时稳定监视；对进 行换型改造，降低厂用电率；通过优化脱硫浆液循环泵运行方式，脱硫塔运行 PH 值等手段，达到提高脱硫效率， 降低脱硫厂用电率的效果。 关键词：脱硫；经济；改造；优化；调整 Abstract: After analyzing the reason of high energy consumption in desulfurization system, which belongs to Datang Huayin Zhuzhou power generation company, we have raised the following transformations: First, in order to improve the density of serous fluid and efficiency of pulping, install the frequency-converter to the recycle pump of ball mill; The second, in order to monitor the parameters real time and long time, change the installation location of densitometer and PH meter in the absorption tower; The third, in order to decrease the station service power consumption rate, change the booster fan according to model; Last,through optimizing the mode of operation desulfurization serous fluid recycle pump, and make good use of PH meter in absorption tower, we have got achievement that increasing desulfurization efficiency and decreasing the desulfurization consumption rate. keywords : desulfurization; economic; modification; optimization; adjustment 1 前言 出力过高，造成磨制浆液密度低；石膏排出泵出力太 株洲电厂 2*310MW 机组是在拆除老厂机组后在原 大，大大超过悬流站出力；密度计和 PH 计设计位置 地以大代小项目,于 2003 年 8 月和 12 月建成投产， 不合理,运行优化有待进一步完善等。脱硫系统运行 工程建设时没有设计脱硫系统,随着国家环保标准日 后，厂用电率达 1.5%,比同类机组高 0.3%左右，就建 益严格