气浮净水自换气溶气法溶解度分析 Analysis of solubility of means of self-changing dissolved air of flotation waste water treatment system.pdfVIP

第22 卷第5 期 辽宁工程技术大学学报 2003 年10 月 Vol.22 No.5 Journal of Liaoning Technical University Oct. 2003 文章编号 1008-0562(2003)05-0676-02 气浮净水自换气溶气法溶解度分析 王广丰 朴明波 李 明 辽宁工程技术大学 机械工程学院 辽宁 阜新 123000 摘 要 对加压气浮净水系统中溶气水饱和溶解度进行了理论分析和量化 认为一般情况下溶气罐中混合气体的饱和溶解度比新鲜 空气低 10%左右 提出一种新的自换气式溶气方法 在不排出溶气罐中旧气体的情况下对其进行强化溶解 再泵入新鲜空气 可使溶 气罐中混合气体的平均亨利常数提高 在相同条件下溶气水的饱和溶解度随之提高 相应的泵水量及系统能耗降低 关键词 气浮净水 溶气效率 溶解度 中图号 X 703.3 文献标识码 A Analysis of solubility of means of self-changing dissolved air of flotation waste water treatment system WANG Guang-feng PIAO Ming-bo LI Ming (College of Mechanical Engineering,Liaoning Technical University,Fuxin 123000,China) Abstract The saturation solubility of means of self-changing dissolved air of the dissolved air flotation waste water treatment system is quantitatively analyzed, theoretically, coming to the conclusion: the saturation solubility of the mixture gases in the saturator is lower than fresh air by about 10% usually. The article offers a new dissolved air means called self-changing in the paper, forcing old gases in the saturator to solution in condition without discharging them, then pumping in fresh air, the mean Henry constant of the mixture gases in the saturator will be increased, and the saturation solubility of dissolved air water will be also increased in the same conditions, the quantity pumped water and the consumption of energy of the system will be decreased simultaneously. Key words flotation waste water treatment efficiency of gas solution solubility 0 引 言 因为新鲜空气由多种气体 主要是N O 和A 成强溶 再泵入新鲜空气 使溶气罐中混合气体 2 2 r 组成 且各种气体在水中的溶解度也不相同 因此 的平均亨利常数提高 在相同条件下可使溶气系 在加压溶气气浮净水系统中 溶气罐进出