泡沫沥青发泡特性及其冷再生混合料性能研究.pdf

学兔兔 公路交通技术 2015年8月 第4期 Technology of Highway and Transport Aug．2015 No．4 DOI：10．13607／j．cnki．gljt．2015．04．O11 泡沫沥青发泡特性及其冷再生混合料性能研究 奎永才 ，卢章天 (1．云南龙瑞高速公路建设指挥部，云南德宏州 665000；2．重庆交通大学土木建筑学院，重庆 400074) 摘 要：选择3种沥青，采用沥青发泡试验就沥青品种、温度及发泡用水量对发泡效果的影响进行研究，并通过无侧 限抗压强度试验、间接拉伸试验以及浸水马歇尔试验、冻融劈裂试验对沥青用量和RAP(沥青路面回收旧料)掺量对 泡沫沥青冷再生混合料力学性能和水稳定性的影响进行研究。结果表明：在所选3种沥青中，相同条件下中海7O 沥青的发泡效果最好，其最佳发泡温度约为160 oC，最佳发泡用水量为2％；RAP掺量增加对混合料水稳定性能不 利；随着RAP掺量增加，混合料无侧限抗压强度和间接拉伸强度逐渐降低；RAP掺量可达70％以上，但应严格控制。 关键词：泡沫沥青；发泡特性；冷再生；强度；水稳定性 文章编号：1009—6477(2015)04—0053—06 中图分类号：U416．217 文献标识码：A Research Off Foaming Characteristics of Foam Asphalt and Performance of its Cold Recycled Mixture KUI Yongcai ，LU Zhangtian Abstract：This paper studies influences of varieties of asphalt，temperature and water consumption for foaming on foaming effect by selecting 3 kinds of asphalt and by means of asphalt foaming test，and studies influences of asphalt dosage and mixing amount of RAP(reclaimed asphalt pavement)on mechanical propeaies and water stability of cold recycling mixture of foaming asphalt via unconfined compressive strength test，indirect tensile test and immersion Marshall test and freeze—thaw split test．The results show that among the selected 3 kinds of asphah，the foaming effect of Zhonghai No．70 asphalt under the same conditions is the best，its optimal foaming temperature is approximate 160~C，and the best forming water consumption is 2％ ；increase of RAP mixing amount is adve~e to water stability of mixture；with increase of RAP mixing amount，the unconfined compressive strength and indirect tensile strength of mixture decrease gradually