柴油发电机组常见的一般故障及排除方法(国外英文资料).docVIP

柴油发电机组常见的一般故障及排除方法(国外英文资料) Common fault and elimination method of diesel generator set (1) a diesel engine can not start a diesel engine at room temperature, normally it should start in a few seconds. Sometimes it is normal to need to repeat one or two times before it can be started. If the diesel engine fails to catch fire after three to four restarts, it should be deemed to be the cause of failure, and the reason is to be determined. Start system failure This kind of failure shows that it cant drive the rotation or start the low speed of low speed, the fault reason, the method of elimination, the following table starts the system failure list The fault phenomenon The cause of the problem Elimination method Diesel engine failure (1) the motor starts and the battery is not electric enough. To activate system circuit connection error or electrical parts. The carbon brush of the starting motor is not in contact with the commutator. Replace the electric battery or the battery in parallel. Check to see if the activation circuit is correct and reliable. To trim or replace the carbon brush, clean the commutator surface with wood sandpaper and blow dust. dynamic (2) compression of air pressure in the receiver is too low. The air distributor is installed in the wrong position. It reinflates. Check and adjust. The failure of the fuel supply system Diesel engine wont start, start the system circuit or all parts are in good condition, should check the fuel supply system, if it is something wrong with the performance of the fuel system is not oil or oil supply is not normal, after the diesel engine does not fire or fire cannot turn into normal operation, and the reason of such fault elimination method, shown in table Fuel supply system failure list The fault phenomenon The cause of the problem Elimination method The diesel engine cannot start (1) the fuel system contains air. (1) check whether the fuel line joints are loose. 1) unscrew the fuel injection pump and the vent on t