造成ro反渗透膜使用寿命减短的原因（The cause of RO reverse osmosis membrane shortens the service life）.docVIP

造成ro反渗透膜使用寿命减短的原因（The cause of RO reverse osmosis membrane shortens the service life） The cause of RO reverse osmosis membrane shortens the service life First, the cause of RO life shortening: 1 reverse osmosis equipment damage caused by improper operation of membrane performance 1.1 reverse osmosis equipment in residual gas running under high pressure, the formation of air hammer will damage the Dow reverse osmosis membrane There are two things happen often: A equipment, emptied, re run, no exhaust gas quickly boost operation. Should be 2 ~ 4bar under the pressure of the remaining air is exhausted, and then gradually boost operation. B, joint between pretreatment equipment and high-pressure pump seal is not good or Water Leakage (especially when the pipeline Water Leakage microstrainer and later) when pretreated water is enough, such as microfiltration clogging, sealed in a bad place because the vacuum can be sucked in air. Should be cleaned or replaced microstrainer, guarantee the pipeline leakage. In short, there should be no bubble in the flow meter under the condition of step operation, during operation should gradually reduce the bubble check reason. Methods 1.2 reverse osmosis equipment shutdown is not correct A, shutdown of rapid decompression without a thorough washing. The concentration of inorganic salt membraneconcentrated water side of the above water, fouling and membrane pollution. B, pretreatment of washing water adding chemical reagent. Because of containing chemical reagents in water equipment during outage may cause membrane fouling. Reverse osmosis equipment in preparation for the shutdown, should stop adding chemical reagent, step-down to about 3bar with good water washing pretreatment 10min, TDS and TDS concentrated water until the water is very close now. 1.3 reverse osmosis equipment disinfection and maintenance lead to microbial contamination This is a composite polyamide membrane are common problems in the use of chlorine resistant polyamid