聚合物驱采出污水深度处理的实验研究.PDFVIP

　 海　洋　石　油 　第30 卷　第 1期 　OFFSHORE　OIL 　　　·81 · 文章编号:1008-2336(2010)01-0081-04 聚合物驱采出污水深度处理的实验研究 马占林, 陈兴原, 李天德 (大庆油田有限责任公司第四采油厂, 黑龙江大庆 163511) 摘　要:以大庆某采出液处理站含聚污水为研究对象, 应用 UV/H O /O 组合对二次除油、过滤后的污水进行了处理实 2 2 3 验, 实验分析了H O 、O 投加量、紫外灯强度、初始 pH 值以及处理时间对HPAM 去除率影响, 确定了合理的组合参数 2 2 3 量;结合初始污水中含油量变化对聚合物和污油去除率的影响进行了实验, 确定了初始污水含油量范围。 并对处理前后 污水对岩心渗透率伤害程度进行实验, 结果表明, 应用高级氧化处理技术处理后的含聚污水水质可以满足污水回注油层 要求, 在现场比较经济可行。 关键词:聚合物驱;采出污水;水处理;水解聚丙烯酰胺 中图分类号:E357.46 　　文献标识码:A 　　doi:10.3969/j.issn.1008-2336.2010.01.081 Study on advanced produced water treatment experiments of polymer flooding Ma Zhanlin,Chen Xingyuan, Li iande (No.4 Oil Recovery Plan t,D aq ing Oilf ield Co.L td ., Daqing 163511) Abstract:Based on the study of polymer-bearing produced water from a produced water treatment station in Daqing Oilfield, a produced water treatment experiment has been done to produced water after secondary degreasing and filtering.Rational combined parameters have been confirmed by the analysis of addition of H2O2 and O3, intensity of UV Lamp, the initial pH value as well as influences of treatment time on HPAM .Experiments hasbeen done on influencesof the oil content changes on polymer and waste oil elimi- nation ratio, and then the range of oil-bearing content of original waste water has been confirmed.Experi- ments of damaging degree of produced water to core permeability before and after treatment show that it is economically feasible to use advanced Oxidation reatment echnology because the water quality after treat- ment can meet the requirements of produced water reinjection. Key words:polymer flooding;prod