流路布置对蒸发器除湿性能的影响.pdfVIP

流路布置对蒸发器除湿性能的影响 1 2 2 2 1 杨哲 ，张浩 ，邓海钊 ，程超 ，刘迎文 （1. 西安交通大学热流科学与工程教育部重点实验室，陕西 西安 710049 ） （2. 广东美的集团股份有限公司，广东 佛山 528311 ） (Tel: 029 Email: ywliu@xjtu.edu.cn) 摘 要：本文模拟研究了四种不同流路布置对于蒸发器除湿性能的影响，结果发现：在相同换热条件下增加流路数可使压 降损失大幅降低，但由于多流程的分流降速作用，制冷剂侧换热系数减小，系统换热及除湿性能不佳；相比而言，两支路流 路布置时除湿量增加约30~70g/h ，对提升除湿能力更有优势；其中UN 顺流布置能够保证空气与制冷剂的温降趋势一致，因 而具有更大的除湿能力和潜热占比，相比于同支路数目的其他流路除湿能力提升约2.4% 。 关键词：流路布置，除湿性能，蒸发器 EFFECT OF CIRCUIT ARRANGEMENT ON THE DEHUMIDIFICITION PERFORMANCE OF EVAPORATOR 1 2 2 2 1 Zhe Yang , Hao Zhang , Haizhao Deng , Chao Cheng , Yingwen Liu (1. MOE Key Laboratory of Thermo-Fluid Science and Engineering, Xi’an Jiaotong University, Xi’an Shannxi 710049) (2. Midea Group Co., Ltd, Foshan Guangdong 528311) Abstract: In this paper, the effect of four different circuit arrangements on the dehumidification performance of evaporator is studied. It is found that under the same heat transfer conditions, with increasing the number of channels, the loss of pressure drop is greatly reduced, but the heat transfer coefficient of the refrigerant decreases which leads to lower capacity of overall heat transfer and dehumidification. In comparison, the dehumidification of the two branch arrangement increases about 30~70g/h, which is more advantageous for the dehumidification performance. Compared with the other circuits with the same branch number, the UN circuit arrangement can get a greater dehumidification and latent heat ratio, and the dehumidification capacity increases by about 2.4% because of the same temperature drop trend between air and refrigerant. Keywords: Circuit Arrange