蒙脱石散制备工艺研究论文.pdf

山西医科大学本科生毕业论文 论文题目 蒙脱石混悬液的制备工艺研究 学生姓名 尉 大 伟 学 号 指导老师 徐 丹 丹 专 业 药 学 班 级 70602 2010 年 6 月 蒙脱石混悬液的制备工艺研究 学生姓名：尉 大 伟 指导老师：徐 丹 丹 【摘 】 目的:研究蒙脱石混悬液制备工艺及质量标准。方法:在蒙脱石混悬 液的制备工艺研究中,本文采取单因素考察方法考察了制备工艺、助悬剂、蒙 脱石与助悬剂用量比等因素，确定了蒙脱石混悬液的最佳制备工艺，考察了制 剂的稳定性并对其做了质量标准研究。结果:采取工艺二，以羧甲基纤维素钠 为助悬剂用量为 0.2%时，混悬效果好、稳定性高、制备方法简单。结论: 用该 法制备的蒙脱石混悬剂的质量标准稳定可靠。 【关键词】蒙脱石；混悬液；制备工艺；助悬剂 ；质量控制； 1 The research of the technology of the preparation of montmorillonite suspension 【 Abstract】 Objective: To study the technology of preparation of montmorillonite suspension and preparation quality standard. Methods: During the research of preparation of montmorillonite suspension, the effect of factor including the technology of preparation, the suspension aid and the ratio of amount of montmorillonite to that of suspension aid on the stability of preparation suspensions were investigated by single-study. Formulation was optimized finally. Meanwhile we have detected preparation quality standard. Results: The formulation is: the second technology of preparation and the 0.2% of amount of montmorillonite to that of Sodium Tylose. Conclusion: The stability of preparation suspension is better. The effects are satisfactory. 【Key Words】 montmorillonite; suspension; the technology of preparation; suspension aid; preparation quality standard 2 蒙脱石混悬液的制备工艺研究 1. 前言 蒙脱石是由 粒极细的含水铝硅酸盐，较早的资料就有