螺杆式冷水机(年度保养)检查报告.doc

Customer Unit Serial No. 客户机组编号 _________________ FILENAME RTHB Maintenance(yearly) 版本号(version):ASTJB-RTHB-M-Y-01.3 RTHB机组年度保养检查报告 Page PAGE 1 of NUMPAGES 9 RTHB Series R? Rotary Chiller 螺杆式冷水机(年度保养)检查报告 Service Excellence North China Service Customer Job Name 客户工程名称 Maintenance Date 保养工作日期 M/D/Y (月/日/年) Trane Job Number 公司工程编号 Job address 工程地点 Unit Model # 机组型号 Unit Serial # 机组出厂编号 The Following Procedures Must be Performed by a Qualified Experienced Trane Service Technician. 以下检查程序项目必须由有经验、有资格的特灵服务技术人员完成 No Yearly Maintenance Procedures 年度保养程序 ? 机组切断供电电源情况下,进行检查的项目部分 NO POWER SUPPLY WARNING: Disconnect All The Electric Power Including Remote Disconnects Before Servicing. Failure To Disconnect Power Can Cause Severe Personal Injury Or Death. 注意:检测前保证确实断开所有电气电源包括远端电源开关.否则可能引起人员伤亡. 1 机组压缩机电机部分 Compressor/Motor 1 检查及收紧压缩机电机电源端子 Check tight all terminal of the motor FORMCHECKBOX 2 检测电机三相线圈温度传感器欧姆值 Test ohm value of the coil temperature sensor FORMCHECKBOX 1-4 ______ ? 2-4 ______ ? 3-4 ______ ? 3 检测电机三相线圈之绝缘阻抗测试Megger Test of the motor FORMCHECKBOX 4 T1 To Earth ____ M? T2 To Earth ____ M? T3 To Earth ____ M? T4 To Earth ____ M? T5 To Earth ____ M? T6 To Earth ____ M? T1 To T2 ____ M? T1 To T3 ____ M? T2 To T3 ____ M? 实测环境温度 Test ambient temperature 环境温度 ambient temperature _________________F/?C 2 机组压缩机电机启动器箱部分 Starter Panel of Compressor/Motor 1 检查及收紧机组启动器箱内所有之电源接线端子Check tight all of terminal of power FORMCHECKBOX 2 检查及收紧启动器箱内所有控制接线端子Check tight all controlled terminal FORMCHECKBOX 3 检测压缩机电机起动器内之所有其它电气装置Check all auxiliary terminal FORMCHECKBOX 4 检测三相电流互感器线圈阻值Test ohm value of the current transformer FORMCHECKBOX CT编号_____________________________ A相 Phase A ______ ? B相 Phase B ______ ? C相 Phase C _____