中汽南方路虎发动机介绍.pptxVIP

中汽南方路虎发动机介绍第1页/共99页 动力总成 V8 自然吸气 / 机械增压 发动机 学员手册第8部分第5 – 71页 由中汽南方蒋凤石翻译第2页/共99页 Powertrain  V8 Engines N/A and S/C Workbook section 8Pages 5 – 71 第3页/共99页 目的 (动力传递部分) 注意：本课程与另外一门课程（Denso发动机管理系统）共同组成发动机部分 的完整介绍。描述4.4 NA和4.2 SC发动机的结构特性介绍各种发动机技术参数按照路虎公司政策进行发动机维修正确使用专用工具 第4页/共99页 Objectives (Powertrain) Note: this course is designed to run along side the Denso Engine management training programmeDescribe the Features of the naturally aspirated 4.4 litre and the 4.2 litre supercharged engineDescribe the technical specification for all enginesCarry out engine repairs in line with Land Rover’s PolicyUse special tools correctly. 第5页/共99页 概述Page 9第6页/共99页 GeneralPage 9第7页/共99页 V8 汽油机90° V型铝制缸体铝制汽缸盖 – 每缸4气门无垫片，挺杆直接作用可变气门正时(VVT) – 机械增压版上未安装初级、次级链式驱动 铝制缸床 (阶梯型结构)碎裂式连杆两根V型驱动皮带电控EGR (机械增压版未装)引入机械增压在Bridgend的发动机厂组装Page 9第8页/共99页 V8 Petrol Engine90° Vee Aluminium cylinder blockAluminium cylinder heads - Four valves per cylinderShim-less, tappet bucketsVariable valve timing (VVT) – not on superchargerPrimary and secondary chain drives Aluminium bedplate (ladder frame)Fracture split connecting rodsTwin multi-vee drive beltsElectronic EGR (no EGR on supercharger)Supercharger introducedBuilt at the Bridgend engine plant.Page 9第9页/共99页 Base EngineAJ-41 V8 NA 发动机是 AJ-33 V8 NA 的改良版新型 AJ-41/43 V8 发动机将投放所有市场变更要点：深式油底壳修正FEAD(发动机驱动风扇) 排放标准达到欧4 US – LEV II修正EGR15,000 英里机油保养 (欧洲), 7,500英里换机油(美国)无回油管路系统修正冷却水出口控制(throttle to different side of vehicle)无垫片第10页/共99页 Base EngineAJ-41 V8 NA Engine is modified version of AJ-33 V8 NA The new AJ-41/43 V8 will be launched into all markets.Key V8 engine changes over the Jaguar version:-Deep SumpRevised FEAD (engine driven fan) Tail pipe emissions Europe ROW – Stage 4 US – LEV IIRevised Exhaust Gas Recirculation (EGR)15,000 Mile Oil Service (Europe), 7,500 miles oil change in USAReturnless Fuel SystemRevised water outlet (throttle to different side of vehicle)Shim-less tappets.第11页/共99页 AJ41 V8 NA发动机线束加油管高度增加改进的缸盖改良水套排气歧管缸床深