SiO2对污泥陶粒性能的影响研究.pdfVIP

中国科技论文在线 SiO 对污泥陶粒性能的影响研究# 2 刘明伟，许国仁，李圭白** （哈尔滨工业大学城市水资源国家重点实验室，哈尔滨 150090） 5 摘要：本文从污泥资源化的角度出发，对给水污泥与污水污泥制备陶粒进行了可行性研究。 SiO2 是污泥原料中含量最高的无机组分，所以文中主要讨论了 SiO2 含量变化多陶粒性能的 影响，分析了不同 SiO2 含量时原料的热力学性质、陶粒的物理性能、表面形态与耐压强度 的变化。结果表明混合物中SiO 的最佳含量范围为22.5%-45% ；3 种不同SiO 含量的原料 2 2 10 的热力学性质只在有机物挥发与碳燃烧阶段有微小差别，其它阶段基本一致；随着 SiO2 含 量的增加，陶粒样品的表面逐渐变得紧凑,耐压强度增加。 关键词：给水污泥；污水污泥；陶粒；SiO2 中图分类号：X705 文献标识码：C 15 Effect of SiO2 on the Characteristics of sludge ceramisite LIU Mingwei, XU Guoren, LI Guibai (State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090) Abstract : From the point of view of the sludge utilizations, the article studies feasibility of the 20 ceramisite making from drinking-water sludge and sewage sludge. SiO2 is the highest content of inorganic components in raw sludge, so the effect of SiO2 content on the characteristics of ceramisite were discussed, and its effect on the thermodynamic properties of raw sludge, physical characteristics, SEM and compressive strength of ceramisite were investigated. Results shown that the optimum range of SiO2 is 22.5%-45%, the thermodynamic properties of raw material with 25 three different SiO2 almost no changing apart from organics volatile and carbon combustion stage. Higher strength ceramsite and more densified surfaces could be obtained as SiO2 contents increase. Key words: drinking water sludge; sewage sludge; ceramisite; SiO2 30 0 引言 城市给水厂在生产饮用水的同