逆流换热节能环保烟火管锅炉的研究论文.pdfVIP

Heat energy-saving boiler fireworks research Chen YaHua Song XuXian Tang ZhenPeng Ning Ke Shenyang institute of special test equipment ，China，shenyang ，zip110035 cyh005@ Abstract ：Now ，Boiler heatHigh temperature flue gas is widely usedWith small fire in the medium heating boiler，Low temperature flue gas boiler with the highest of the heat transfer medium heat downstream ，And downstream very heat energy is wasted 。According to Newtons heat transfer equation ，Two ways ：One is to increase the temperature pressure train t△t ；Two is to increase the heat transfer coefficient K 。Temperature, pressure increases, it also has two train t ways ：One is changeless, improve t1, t2 to strengthen and improve the combustion chamber smoke temperature, Two is changeless, is the same as t1 with relatively low temperature flue gas medium heat, Smoke will face in the boiler heat for the high temperature of the water boiler steam boiler export (e.g., saturation vapor pressure 0.8 Mpa 174.5 degrees Celsius) and change the temperature for gas boiler heat for the lowest temperature (such as steam boiler pressure 0.8 Mpa, boiler make-up water temperature is 20 ° c), Reduce t2, effectively reduce exhaust temperature, temperature, pressure, improve, improve the efficiency of heat transfer and save energy boiler.Countercurrent. Keywords: counter flow heat exchange 逆流换热节能环保烟火管锅炉的研究 陈雅华 宋绪鲜 唐振鹏 宁科 沈阳市特种设备检测研究院，中国，沈阳，110035 cyh005@ 【摘要】目前，锅炉换热广泛采用较高温度烟气与较低锅炉内介质换热，较低温度烟气与最高锅炉内介质换热 的顺流换热方式，而顺流换热方式非常浪费能源。按牛顿传热公式，有两个途径：一是增加温压△t；二是增加 传热系数K。增加温压△t它也有两种途径：一是t 不变，提高t ，这就要强化燃烧，提高炉膛烟气温度，三是t 2 1 1 不变，就是同样的烟气温度与较低温的介质换热，将烟气换热面为锅炉内上部的最高温的锅炉水汽出口（如蒸 汽锅炉运行