ppt课件-cogenerationprojectatfuelin1998-afrepren.pptVIP

COGENERATION PROJECTPERFOMANCE OF THE COGEN PLANT1998 BY GAIQUI Vivian FUEL Steam Power Generation Existing Plant No. 1 BOILER Fives Cail Babcock Rating:110T on Bagasse Mode 90T on Coal Mode Steam Pressure:45bars Steam Temp: 450°c TURBO GENERATOR GROUP Creusot Loire/Jeumont Sneider Power: 21.7 Mw Extraction Pressure:1,5bar Condensor Capacity:110t FUEL Steam Power Generation Power Plant No. 2 BOILER John Thompson Africa Single Pass/Suspended boiler Rating:100 T on Bagasse Mode 80 T on Coal Mode Steam Pressure:45 Bars Steam Temp: 450 °c TURBO GENERATOR GROUP ABB/SIEMENS Extraction Condensing Power: 18.8 Mw Extraction Pressure:1,5bar Condensor Capacity:100t POWER PLANT 1 2 (steam Power) Advantages High overall efficiency Any type of fuel may be used (Bagasse/Coal)separately or in combined mode Heat to power ratios can be varied through flexible operations Ability to meet more than one site heat grade requirement Wide range of sizes available Long working life THE BOILER The choice was a JOHN THOMPSON AFRICA Boiler with operating pressure of: - 4500 Kpa with a mean temp. of 440oc (same working pressure as Boiler No.1) These specific conditions were chosen to optimize the power generation capacity while at the same time refraining the need for sophisticated and high cost of water treatment. THE DEMIN PLANT After a survey of the existing Demin Water Plant and in addition of the return condensate from the Sugar Factory Process Results shows that the existing DEMIN WATER PLANT was enough efficient and sufficient for the 2 boilers need. Flow Rate service:15m3/hr Capacity:250m3 nett. Between regeneration Raw water quality: Cations 91mg/l Anions 71mg/l pH 6,5-7,5 Operating pressure: 500kpa JTA BOILER EFFICIENCY To maintain the steam temp.within the close limits requi