亚临界300MW机组改造为超超临界叠置循环的技术方案研究_20110109.pdf

1,2 3,4 330032 2 330006 3 710032 4ABB 300MW 700MW 4.5% 300MW TM 621 A 1002-1140 201101- A Brief Discussion on the Retrofit Scheme of Domestic Subcritical 300MW Units by Upgrading Them into Serial Ultra-Supercritical Cycle Unit WU Yi-qiang1,2 SHU Kwan Chin 3,4 ( Jiangxi Vocational Technical College of ElectricityNanchang 330032China 2Jiangxi Chengda Engineering Consulting Supervision Co., LtdNanchang 330006China 3Used to work with Xi’an Thermal Power Research InstituteXian 710032China 4Used to work with ABB Power Generation LtdHong KongChina Abstract Technical suggestion for the retrofit of 300MW subcritical units in service was proposed. It is suggested that a new ultra-supercritical backpressure turbine be installed in front of two existing subcritical 300MW turbines to supply steam for the latter, so as to form a more efficient overlying ultra-supercritical cycle unit; besides, the control stages of the 300MW turbines be eliminated to further increase the efficiency of the whole unit. A new ultra-supercritical non-reheat boiler will be built to supply live steam to the backpressure turbine, whereas the existing boilers will be retrofitted to supply reheat steam. A serial booster pump was recommended to add to the feedwater supply system to utilize the existing equipment as far as possible. As a result, a 700MW ultra-supercritical unit with 3-boilers, 3-turbines is established. Heat rate is expected to be decreased by 4.5% after re