扩体错流式生物滴滤床净化甲苯废气.pdfVIP

环榄污染与防治第 31 卷第11 期 2009 华 11 月 扩体错流式生物滴滤床净化甲苯废气 常小军李!畏精刘位彭淑蜻刘春欲念毓袅 Ut京工业大学环绕与能源工程学院，北京 100124) 摘要 采用自行设计制作的扩体错流式生物淌滤床，以用笨为自标·污染物、陶赖为填料、恶臭假单胞西哥为商激进行实验，研究 了扩体鳞流式生物满滤床的挂膜启动情况、!fl苯进口浓度、停留时间对净化效率的影响。结果表明，(1)环境温度为 17-23 C.扩体 错流式生物淌滤床在 10 d 内究成挂膜启动，比传统生物滴滤床缩短了 4ι(2)甲笨净化效率随迸口浓度的增加而逐渐下降，当甲 3 3 苯进口质11浓度为 1100 mg!m 时，净化效感为 95%; 均甲盖在进口质般浓度维持在 1100-1200 mg!m 肘，随停留时间的缩短，甲笨 净化效率下降。 (3) 当停留时间分别为 94 、 63 、 48 s 时，甲苯净化效率分别为 87%-92% 、 70%-74%、 60%-62% ， 关键词扩体错流生物滴滤思奥假单胞菌甲笨 Purification of toluene contained w附te gas by enlarged cr喃喃s-flow bicrtrickling filter Zhang Xiaojun. Li]ian .Liu] Îa. Peng Shujing .Liu Chunjing.] in Yuquan. (College of Environment and Eneγgy Engineering .Beijing University of Technology.Beijing 100124) Abstract: The toluene degraded bacterial was inoculated on an enlarged cross伽 flow bio-tricking filter with Pseudomonas putida as cultured strains. The stat-up process of the filter was studied and effects of inlet concentration and residence time on toluene removal capacity were investigated. The results indicated that given the surrounding temperature of 17 c to 23 C •the tested filter completed start-up process in 10 d ,which was 4 d earlier than that of traditional bio-trickling filter. With inlet concentration of less than 1 100 mg/m门95 % of toluene was removed. while the removal efficiency was decreased with increasing of inlet concentration. when the inlet toluene concentration ranged from 1 100 mg/m3 to 1 200 mg/m3 • the removal efficiency of the filter kept 87 %-92 % at the residence time of 94 s. Reduce the residence time could decrease