低浓度甲烷氧化燃气加热启动实验研究.pdfVIP

中国工程热物理学会 燃烧学 学术会议论文 编号：104216 低浓度甲烷氧化燃气加热启动实验研究 1 2 2 2 1 吕元 ，姜凡 ，肖云汉 ，穆克进 ，周娴 (1. 中国科学院研究生院，北京市 海淀区 100190； 2. 中国科学院先进能源动力重点实验室（工程热物理研究所），中国科学院能源动力研究中心，北京 市 海淀区 100190) Tel：010Email：luyuan305@mails.gucas.ac.cn 3 摘要：针对处理量为 1000Nm /h 的逆流式煤矿通风瓦斯热氧化试验装置，提出燃气加热启动方式。燃 气加热启动在启动时间与运行成本上都优于常规的电加热启动。设计了燃气加热启动装置，并搭建了 实验台。通过调试实验，实现了装置的加热启动，并针对启动时间、切换时间、通风量等操作参数进 行了实验研究。实验结果表明，启动燃烧器可在4 小时内实现装置的预热启动，使蓄热体内温度场达 到实验所需的理想温度场，并确定了装置运行实验所采用的常规启动方式与各启动参数。 关键词：通风瓦斯；热氧化；燃气加热；实验研究；蓄热体 Experimental Study of a Fuel Gas Heating Device of Low Concentration Methane Oxidation 1 2 2 2 1 LÜ Yuan , JIANG Fan , XIAO Yun-han , MU Ke-jin , ZHOU Xian (1.Graduate University of Chinese Academy of Sciences, Haidian District, Beijing 100190, China; 2. Key laboratory of Advanced Energy and Power(Institute of Engineering Thermophysics), Research Center of Energy and Power, Chinese Academy of Sciences, Haidian District, Beijing 100190, China) ABSTRACT: For start-up of ventilation air methane (VAM) oxidation experimental set-up with a capacity of 1000 Nm3/h, a fuel gas heating system was put forward. The fuel gas heating start-up method has a shorter start time and lower cost than electric heating method. A fuel gas heating system was designed and an experimental device was built up. The VAM oxidation device can be successfully started using the fuel gas heating device A series of experimental study were carried out with the variation of start time, switching time, air flux. Experimental results sho