实际高维转子轴承系统非线性动力学行为研究.pdfVIP

第八届全国振动理论及应用学术会议论文集，上海，2003 年 11 月 实际高维转子—轴承系统非线性动力学行为研究 1 1 2 3 荆建平 , 孟光 , 孙毅 , 夏松波 (1. 上海交通大学 国家振动、冲击和噪声重点实验室, 上海 200030 ；2. 哈尔滨工业大学 航天工程与力学系，哈尔滨 150001； 3. 哈尔滨工业大学 能源科学与工程学院，哈尔滨 150001） 摘 要： 本文采用等参梁有限元方法对实际 600MW 汽轮发电机组的轴系，考虑局部非线性油膜力因素， 进行了动力学响应分析；并与线性方法分析结果进行了对比。同时考察了直接积分法和模态叠加法在大型 轴系非线性求解方面的差别，结果表明：采用非线性方法求解高维转子轴承系统的动力学响应是必要的而 且是可行的；对于转子系统非线性动力学问题，直接积分法比模态叠加法更为有效。 Study on the Nonlinear Dynamics of a Real Large-Scaled Dimension Rotor-Bearing System 1 1 2 3 JING Jian-ping , MENG Guang , SUN Yi , XIA Song-bo (1. The State Key Laboratory of Vibration, Shock Noise, ShangHai JiaoTong University, Shanghai 200030; 2. Department of Astronautics and mechanics, Harbin Institute of Technology, Harbin 150001; 3. School of Energy Science and Engineering, Harbin Institute of Technology, Harbin 150001.) Abstracts: In this paper, the dynamic response of the rotor system with local nonlinear lubricating force factors of a 600MW steam turbine generator is analyzed by employing equal-parameter beam element method. The result is compared with those from linear method. Simultaneously, the difference of Direct Integration method and Mode Superposition method in nonlinear problem solving is also checked. The result shows that using nonlinear method to solve the dynamic response of a large-scaled rotor-bearing system is necessary and practical; For a nonlinear dynamic problem of a rotor system, the Direct Integration method is more effective than the Mode Superposition method in solving the problem. ───────────────── 基金项目：国家高技术研究发展计划(863)资助：课题编号 2002AA412410 作者简介：荆建平（1969－），哈尔滨人，博士后