超大直径筒仓仓顶现浇混凝土施工悬吊支撑桁架安全分析.docxVIP

超大直径筒仓仓顶现浇混凝土施工悬吊支撑 桁 架 安 全 分 析李勤山1，3王铁成1，2赵海龙1，2( 1. 天津大学建筑工程学院，天津 300072; 2. 滨海土木工程结构与安全教育部重点实验室，天津300072;3. 平煤神马建工集团有限公司，河南平顶山467000)摘 要: 以旋转盘口式扣件钢管桁架支撑体系为研究对象，针对筒仓施工中支撑平台可能出现的局部拉索或杆件失效，利用 ANSYS 软件建立剩余结构有限元模型并进行数值分析。考虑两种最不利施工工况: 局部 拉索失效，分析局部受力杆件失效时结构的承载能力。分析结果表明: 当第一圈拉力最大的悬吊钢绞线失效 后，其余钢绞线通过应力重分 布，使桁架竖向位移略有增加，钢绞线应力增大，但 仍 能提供桁架承担施工荷 载; 当桁架下弦杆中应力最大的杆件失效、桁架上弦杆和斜杆失效后，对结构影响都较小，不影响结构承担施 工荷载，支撑体系具有较高的安全性。关键词: 筒仓仓顶; 旋转盘口; 支撑体系; 承载力; 失效DOI: 10. 13204 / j． gyjz201501029THE SAFETY ANALYSIS OF SUSPENSION SUPPOＲT TＲUSS ON TOP OFLAＲGE-DIAMETEＲ SILO UNDEＲ CONCＲETE CONSTＲUCTIONLi Qinshan1，3Wang Tiecheng1，2Zhao Hailong1，2( 1. School of Civil Engineering，Tianjin University，Tianjin 300072，China;2. Key Laboratory of Coast Civil Structure Safety ( Tianjin University) ，Ministry of Education，Tianjin 300072，China;3. Pingmei Shenma Construction Engineering Group Ltd，Pingdingshan 467000，China)Abstract: The steel-tube truss supporting system made of rotating-fastening members was studied，a FE model of theremaining structural model was established by ANSYS software to do experimental research and analyze local cablefailure or member failure of the support platform during silo construction，which would occur． Two of the mostunfavorable conditions of construction were considered，one was the bearing capacity of the structure when local cablefailed，the other was local stressed member failure． The results showed that when failure occurred in the first lapsuspension strand with maximum tension，the rest of the strand through the stress redistribution，truss verticaldisplacement increased slightly，strand stress increased，which could still provide truss to undertake constructionload． There would be less impact after the members with largest stresses of the bottom chord，as well as the upperchord and the diagonals of the truss failed，which could not influence the ability of the structure to bear constructionloads，hence the support system has a higher secu