EH36高强度船板钢奥氏体连续冷却转变行为的研讨.pdfVIP

EH36 高强度船板钢奥氏体连续冷却转 变行为的研究 1 1 1 1 1 2 2 邱春林，王建刚 ，高秀华 ，宋振官 ，齐克敏 ，孙卫华 ，孙浩 （1．东北大学轧制技术及连轧自动化国家重点实验室，沈阳110004; 2．济南钢铁股份有限公司技术中心，济南250101） 摘 要：利用GLEEBLE 2000 热模拟实验机，对EH36 船板钢连续冷却相变行为以及在增速 冷却和减速冷却条件下相变行为进行了研究。结果表明，在连续冷却条件下，在400~650 ℃ 温度范围内，冷却速度ν在 4~16 ℃/s 之间时，相变组织以贝氏体组织为主；在冷却速度ν ≥1℃/s 时，先以一定速度v 冷却至600℃，然后将冷速减半时，其显微组织与0.5 ν恒速冷 却组织相近；而先一定速度v 冷却至600℃，然后将冷速增倍时，其显微组织与2 ν恒速冷 却的显微组织相近。实验结果为制定EH36 船板钢的控轧控冷工艺提供了理论基础。 关键词：EH36 船板钢；奥氏体；连续冷却；相变 中图分类号：TG111.7 文献标识码：A Investigation on Transformation Behavior of Austenite of EH36 Ship Plate Steel during Continuous Cooling 1 1 1 1 1 QIU Chun-lin ，WANG Jian-gang ，GAO Xiu-hua ，SONG Zhen-guan ，QI Ke-min ，SUN 2 2 Weihua ，SUN Hao （1．The State Key Laboratory of Rolling and Automation，Northeastern University ， Shenyang 110004 ， China ； 2 ．Jinan Iron and Steel Group Co. ， Jinan 250101) Abstract: Using GLEEBLE 2000 thermal-mechanical simulator ， the phase transformation behavior of EH36 ship steels was studied after cooling with constant， increasing and decreasing rate ， respectively. Results show that the ultimate microstructure is mainly bainite when the cooling rate is 4~16 ℃/s and the temperature is located in the range of 400~650 ℃ during continuous cooling; After cooling to 600 ℃ with 1 ℃/s or higher constant rate at first stage and then with the rate of half the initial value， the final microstructure is similar to that achieved after cooling with the second stage rate constantly. Furthermore ， if the cooling rate at the second stage is double the initial rate ， the micros