美国胜达因磁力泵介绍.ppt

These graphs show typical Torque / Temperature curves, and show that at high temperatures the strength of the magnets is less. Note that HMD use the highest grade of Samarium Cobalt magnets, and the safety factors built into the HMD magnet drive design ensure that full power is available up to the maximum synchronous operating temperature of 260C. All the parts indicated are refered to as the Cartridge. Basically it is the liquid contact parts except the casing. A front neck ring is always included . As seen this part is easily interchageable. Later on in the course the fitting of this is included . This slides no secret…it’s intuative…but highly worth revisiting the message of the ealry 90’s….remove the seals and bearings and not much else resides! 集装式组件 Reset Mode Power = kW (%) Max. Limit (%) Min. Limit (%) Start Timer (S) Reaction Timer (S) Hysteresis (%) Current Range (A) 52 Relay On 压差开关 温度探头 液体泄漏探头 防干转功率 保护器 泵的保护和状态监测 停车或报警:- 泵干转, 料罐抽空 小流量, 关阀操作 严重汽蚀 磁力耦合脱转 介质粘度骤减 介质粘度骤增 转动部件咬死 超载 Reset Mode Power = kW (%) Max. Limit (%) Min. Limit (%) Start Timer (S) Reaction Timer (S) Hysteresis (%) Current Range (A) 52 Relay On magsafe防干转功率保护器 磁力泵与其他类型泵的比较 屏蔽泵 屏蔽泵的构成 机械密封泵 传统的双端面机械密封泵 复杂的密封支持系统 机封肯定会泄漏 为什么传统离心泵停车检修? 80% 密封与轴承损坏 20%其它 机械密封泵悬臂式泵轴的挠性 连轴器 过流部件 其它 垫片 轴承 密封装置 0 20 30 40 50 60 70 10 % 机械密封泵损坏分析 泵的轴承位置 双端面密封泵 屏蔽泵 磁力驱动泵 机械密封泵 屏蔽泵 磁力泵 1. 泄漏 2. 复杂的机械密封 及其配管 3. 密封及轴承维修 率高 1. 无泄漏 2. 无需机械密封 3. 返回制造厂维修- 成本高，周期长 4. 石墨轴承- 易磨损 5. 内部间隙小- 不耐颗粒 1. 无泄漏 2. 无需机械密封 3. 现场维护简单 4. 碳化硅轴承- 寿命长 5. 内部间隙大- 耐颗粒 API - 685 磁力驱动 低温型 1 2 3 4 5 6 7 8 9 % 工业 1 24 电力及石化 2 0.5 木材及造纸 3 0.5 军工 4 42 化工 5 0.7 水处理 6 0.2 采矿及冶金 7 24 医药 8 6 油脂 9 2 食品 磁力泵应用行业分布 总 结 无泄漏磁力驱动泵给用户带来$$$$$$和“放心” 简单, 低安装成本 零泄漏工艺 增加了安全性和可靠性 减少了维修, 增加了运行时间 泵的整个寿命周期里成本最低 This is a build slide: General service pumps might be of the cast iron / bronze fitted configuration and represent the greatest installed base across a broad category of markets. The next tier