不同替代率下机制砂混凝土抗压强度的试验研究.docxVIP

不同替代率下机制砂混凝土抗压强度的试验研究 何盛东〔％刘立新X王华％王瑞利4 (1.郑州大学土木工程学院?河南 郑州450001 ； 2.郑州路桥集团发展公司，河南郑州450052； 3.新疆交通职业技术学院公路工程管理系，新疆乌鲁木齐831401： 4.中交烟台环保疏浚有限公司，山东烟台264009 摘 耍：抗压强度是混凝土的一项币要力学性能，为研究机制砂混凝土的抗压强度的变化规律，以选用的机制砂配制C50混凝土，在水 泥用呈和砂率保持不变的情况下，改变机制砂对天然砂的取代率(0、30%、50%、70%、100%) °通过比较分析试验数据得出以下结论：机制 砂混凝上抗压强度大于天然砂:机制砂混凝七抗压强度随龄期的增长和替代率的提髙而增大。混凝七在此基础上确立该机制砂的最佳裨 代率为50% , 关键词：替代率：机制砂：混凝土：抗压强度 屮图分类号：TU528.01 文献标志码：A 文章编号：1002-3550(2010) 10-0109-03 Experimental research on compressive strength of manufactured sand concrete in different replacement ratios HE Sheng-dong1-2, LIU Li-xin1, WANG Hua3, WANG Rui-li4 (1. School of Civil Engineering, Zhengzhou University, Zhengzhou 450002. China； Construction and Development Company of Zhengzhou Road Bridge Group Co., Ltd., Zhengzhou 450052, China； Department of Highway Engineering Management,Xinjiang Vocational Technical College of Communications, Urumqi 831401 .China； China Communications Yantai Environmental Dredging Co., Ltd.. Yantai 264005.China) Abstract: Compressive strength is one of the important mechanical properties of conerete, in order to study the change of compressive strength of the manufactured sand concrete at different replacement.C50 was preparated at the same sand ratio and cement consumption with the replace ment ratios of manufactured sand by mass to the natural sand were 0?0.30,0.50,0.70 and 1.00 respectively.Based on the test data,the conclusion? were found such as the compressive strength of manufactured sand concrete was greater than natural sand concrete,the compressive strength o manufactured sand concrete had the trend of growing with ages increased and the replacement ratio increasing. Basted on this .that the optimum re? placement ratio was 50% of the concrete was suggested? Key words: replacement ratios：manufatured sand：concrete：compressivestrength 0引言 随着基础建设的快速发展，可利用的天然砂资源越来越少， 日益不能满足基建规模的需求，利用广泛分布岩石和矿渣生产 机制砂代替天然砂将口益受到重视。抗压强度是混凝士的i项重 要力学性能，对机制砂混凝土的推广应用具有重要的决定作用。 目前，国内针对夭然砂与机制砂混凝土抗压强度的硏究主 要冇:李溪通过研究得出，在水灰比相同的情况下，机制砂混