03-Emergency generator.docVIP

Emergency generator 应急发电机 Safety device test of emergency diesel engine Refer to “Test program ( machinery part”. The principle particulars of the emergency generator are shown in attached sheet table 1-1. 1.1应急发电机安全装置试验 本试验参照轮机部分系泊试验大纲进行 应急发电机重要数据见表1-1。 Insulation resistance test Measurements of insulation resistance shall be carried out by a DC500V Megger meter before and after load test, test results shall be recorded. The above results are recorded in attached sheet table 1-2. (not less than 1M( in hot condition and 5M( in cool condition). Note: An ohmmeter shall be used for semi-conductive rectifiers. 1.2绝缘电阻试验 发电机负荷试验前和试验后，用直流500伏兆欧表测量绝缘电阻并记录（热态不小于1M(, 冷态不小于5M( ）。试验结果记录于表1-2。 注: 对于半导体整流器，本试验应使用万用表测量其绝缘电阻，试验时应与主电路断开。 Load test A load test of generators to be done by means of an adjustable water resistance (cos( = 1) connected to busbar of ESB. The generator to be running at 25%, 50%, 75% load for 15 minutes and at 100% load for 4 hours, 110% for 15 min. After load test, temperature rise of the generator shall be measured and recorded. 1.3负荷试验 调节连接在应急主配电板汇流排上的水电阻负载，进行发电机负荷试验。空载运转5分钟，25％，50％，75％负荷时各运转15分钟，在100％满负荷地运转4小时。在110%超负荷地运行15分钟. 负荷试验后，测量发电机各相绕组温度并记录。 Voltage characteristic test of emergency generator set At first emergency generator is adjusted to rated voltage frequency. Then check steady voltage frequency variations from full load to no load and back to full load. In each step, the value of voltage frequency shall be measured and recorded. The measurement results are recorded in attached sheet table 1-3. It is to be verified that variation of voltage and frequency is within allowed limitation. Voltage variations: (2.5% of rating voltage ((11.2V) Frequency variations: (5% of rating frequency ((3Hz) 1.4应急发电机电压特性试验（COSφ=1） 把应急发电机调整到额定的电压和频率，然后从满载到空载再返回到满载使电压和频率的变化得以稳定。测量并记录每档电压和频率的变化值。记录表1-3。 电压变化： 额定电压的(2.5％之内（(11.2V） 频率变化: 额定频率的(5％之内（(3HZ） Transient voltage test of emergency generator set This test shall be verified that transient vo