原料预混处理在造纸法再造烟叶生产中的应用研究.docVIP

原料预混处理在造纸法再造烟叶生产中的应用研究 刘恩芬 李波 武士杰 陈正春 龚永康 王茜茜 周国福 云南中烟再造烟叶有限责任公司 云南中烟工业有限责任公司技术中心 X 关注成功！ 加关注后您将方便地在 我的关注中得到本文献的被引频次变化的通知！ 新浪微博 腾讯微博 人人网 开心网 豆瓣网 网易微博 摘????要： 利用源于4个烤烟主栽区的烟梗、末棒及烟叶碎片等3类再造烟叶原料, 通过生产实验, 探讨了3类再造原料化学成分的均匀性和预混处理对原料均匀化、产品批次间化学成分稳定性的影响。实验结果表明:烤烟生物学特性和气候环境条件决定了烟梗、末棒及烟叶碎片3类原料的钾、总氮、烟碱等化学成分含量差异性, 其差异性达到极显著水平 (P0.05) , 并且空间变异度较大 (12.70%66.02%) 。预混处理能显著提高烟梗、末棒及烟叶碎片等3种原料的均匀性, 各类原料的各项化学成分含量的变异系数都能稳定在5%内。预混处理对产品批次间的质量稳定具有较好作用, 尤其是总氮、烟碱、钾和氯的含量, 在批次间的差异性未达到显著水平 (P0.05) 。 关键词： 烟梗; 末棒; 烟叶碎片; 再造烟叶; 预混处理; 作者简介：刘恩芬 (1969─) , 女, 工程师, 主要从事分析检测研究。 收稿日期：2017-08-14 基金：云南中烟重点科技项目“再造烟叶生产废水零排放关键技术研究及应用” (2015GY01) Research on Application of Raw Materials Premixed Processing in Production of Reconstituted Tobacco by Paper-making Process LIU En-fen LI Bo WU Shi-jie CHEN Zheng-chun GONG Yong-kang WANG Qian-qian ZHOU Guo-fu China Tobacco Yunnan Reconstituted Tobacco Limited Company; Technology Center, China Tobacco Yunnan Industrial Limited Company; Abstract： The tobacco stem, tobacco stick and tobacco scrap from 4 major tobacco production regions were used as the raw materials of paper-making reconstituted tobacco. The effects of raw materials premixed processing on the uniformity of chemical compositions in raw materials and the stability of chemical compositions in different batches of reconstituted tobacco products were researched through production experiments. The experimental results indicated that the biological characteristics of flue-cured tobacco and the climatic conditions decided the differences in chemical compositions among 3 types of raw materials; there were very significant differences in the content of potassium, total nitrogen and nicotine among tobacco stem, tobacco stick and tobacco scrap, and their spatial variability was relatively big ( 12.70% ~ 66.02%) . Raw materials premixed processing could dramatically improve the uniformity of raw materials. The variation coefficients of content of various chemical compositions in three types of raw mater