纯电动城市空调公交车动力系统设计与开发研究-车辆工程专业论文.docxVIP

ABSTRACT This paper describes that the author made parameters matching design and modeling simulation research of the electric bus power system by using the professional software CRUISE, based on the project of trial-producing 10-meter city electric bus by author’s company cooperating with Jiangsu MuDan Bus enterprise, to achieve 2 goals, one is to test the vehicle performance with the above parameters and prove the design project right or not, the other purpose is to preliminarily define certain control numbers by simulating different design parameters. Firstly, to realize the design target, it is taken that calculating battery and motor key parameters, selecting models and fixing up power train, on the basis of original bus available space and set load. Secondly, it is run in CRUISE software after building the power subsystems and whole vehicle model, inputting calculating data, connecting mechanical and electrical interface and setting simulation tasks, where the cycle run simulation task, Thirdly, according to simulation results, design project was proving appropriate. It was obtained that air conditioner influence extent if it works, and calculating how much energy was cost and the efficiency in energy transfer. Tentatively, brake-backup power trend was acquired. Finally, real electric bus test is taken .It is proved rationality that design project with power system parameters by test results. Key words: Electric Bus, Matching design, Modeling simulation 目 录 HYPERLINK \l _bookmark0 第一章 绪论 1 HYPERLINK \l _bookmark1 1.1 引言 1 HYPERLINK \l _bookmark2 1.2 纯电动汽车动力系统设计与仿真发展现状 1 HYPERLINK \l _bookmark3 1.3 课题来源及主要研究内容 3 HYPERLINK \l _bookmark4 第二章 纯电动汽车动力系统方案设计与选型 5 HYPERLINK \l _bookmark5 2.1 纯电动公交车开发项目简介 5 HYPERLINK \l _bookmark6 2.2 原车结构及参数 5 HYPERLINK \l _bookmark7 2.3 纯电动公交车设计目标 7 HYPERLINK \l _bookmark8 2.4 纯电动公交车动力系统匹配选型 7 HYPERLINK \l _bookmark9 2.4.1 变速箱选型 7 HYPERLINK \l _bookmark10 2.4.2 主减速器参数确定 8 HYPERLINK \l _bookmark11 2.4.3 驱动电