[QC]降低软土地基PHC管桩损伤率.docVIP

- PAGE 18 - 2009年全国工程建设 优 秀QC 小 组 活 动 成 果 交 流 会 资 料 降低软土地基PHC管桩损伤率 执笔人、发布人：×× 福州××建筑有限公司 福建××技术学院校区（二期）工程基础施工QC小组 2009年4月 目 录 一、前言 ························································································ 3 二、QC小组简介 ··············································································4 三、课题选择 ··················································································· 5 四、现状调查 ······················································································5 五、活动目标及设定依据 ··································································· ···7 六、原因分析 ···················································································8 七、要因确认 ················································································ 9 八、制定对策 ···················· ···· ···························································12 九、对策实施 ················ ······························································· 12 十、效果检查 ·········· ······································································16 十一、巩固措施及标准化···································································17 十二、总结及今后打算 ·································································18 附录 合理化建议一览表 ·············································································19 QC小组活动一览表 ······································································19 前 言 福建××技术学院校区（二期）学生宿舍、食堂为福建省重点工程。本工程设地下室一层，上部由南北两栋主楼组成，其中南楼13层、北楼15层，南北楼之间为两层连体裙房, 总建筑面积24917 m2，建筑总高度为66.55 本工程桩基设计总桩数为314根，桩身强度为C80,桩型为PHC400-95-A（40根）PHC500-100-A（274根），采用ZYJ680B静压桩机进行沉桩施工、基坑土方采用机械和人工开挖相结合进行分层分段开挖。 本工程质量目标为争创福建省“闽江杯”优质工程，要求基础工程质量必须达到优良标准。因此，控制PHC管桩的桩身质量，降低管桩因桩基施工及土方开 图1 软土地基施工现场 挖过程中造成的倾斜及断裂等损伤频率就成为本工程的一项重要课题。 面对此课题，项目部成立了QC攻关小组，组织项目部成员和施工班组对桩基施工和土方开挖方案进行了广泛的讨论，并对本地区以往施工的同类桩基工程进行了调查和分析，提出了优化方案和质量控制措施，尔后付诸实施。 二、QC小组简介 表1 QC小组名称 福建××技术学院校区（二期）学生宿舍、食堂工程QC小组 成 立 日 期 2008 登 记 日 期 2008年7月3日 注 册 号 FZTJ-2008-038-045 QC