钢渣高性能混凝土抗冲耐磨性能试验.pdfVIP

第34卷第6期 水 利 水 电科 技 进 展 2014年11月 Vol.34 No.6 Advances in Science and Technology of Water Resources Nov. 2014 DOI:10.3880/ j.issn.1006 7647.2014.06.009 钢渣高性能混凝土抗冲耐磨性能试验 信玉良,侍克斌,努尔开力 ·依孜特罗甫,吴福飞 (新疆农业大学水利与土木工程学院,新疆 乌鲁木齐摇 830052) 摘要:为有效利用大宗废料钢渣,设计制作了15 组掺钢渣粉混凝土试件,试验研究钢渣粉掺量对混 凝土的工作性能、力学性能及抗冲耐磨性能的影响极其作用机理。 结果表明:钢渣粉可以改善混凝 土的工作性能;在不同水胶比下,掺钢渣粉混凝土的早期强度均小于基准混凝土,钢渣掺量在10% ~30%以内时,混凝土的后期强度与基准混凝土基本持平,且略有提高,钢渣掺量大于30%时混凝 土的后期强度下降较大;采用水下钢球法测试混凝土28d抗冲磨强度,得出钢渣掺量在 10%以内 时混凝土的抗冲磨强度比基准混凝土略有提高,当钢渣粉掺量大于20%时,混凝土的抗冲磨强度 呈下降趋势。 因此,钢渣粉作为混凝土掺合料时其掺量应控制在20%以内为宜。 关键词:钢渣粉;高性能混凝土;工作性能;力学性能;抗冲耐磨强度 中图分类号:TU528摇 摇 摇 文献标志码:A摇 摇 摇 文章编号:1006 7647(2014)06 0040 05 Study on the abrasion resistant properties of high performance concrete with steel slagpowder/ / XINYuliang,SHI Kebin,YIZITELUOPU Nuerkaili, WU Fufei(The College of Civil and Hydraulic Engineering, Xinjiang Agricultural University,Urumqi830052,China) Abstract:In order tousealargeamountofindustrialwastemoreefficiently,15groupsofconcretespecimenswithdifferent contents of steel slag powder (SSP)were designed and produced. An experimental study with a special emphasizes on the influence of SSP contents on the workability,mechanical properties,and abrasion resistance of concrete was carried out. Thetest results showed that theworkability of concrete could be improved by steel slag powder,and in the different water glue ratio,the early strengthofconcretewithsteelslagpowderislessthanthereferenceconcrete. Whenthedosageof steel slag iswithin 10%鄄30%,the late strength of concretewith steel slag powder is approximately equal or slightly higher than the reference concrete. Whilethe dosageof steel slag isgreater than30%,thelate strength of concrete decreasedgreatly. In