气升式膜过滤装置纳滤杆菌肽酸性水溶液的研究.pdfVIP

气升式膜过滤装置纳滤杆菌肽酸性水溶液的研究* 1 1 1 1 石风强 ，何华婷 ，景文珩 ，邢卫红 1 （南京工业大学材料化学工程国家重点实验室，江苏 南京 210009 ） 摘要：本文通过气升式膜过滤装置，采用孔径为0.9nm 的TiO2 陶瓷纳滤膜，对杆菌肽酸性水溶液过滤进行 了研究，系统地考察了曝气量和跨膜压力对过滤性能的影响。结果表明，曝气可有效减轻浓差极化；当跨 膜压力为0.3 MPa，稳定通量和稳定截留率随曝气量均呈先增大后减小的趋势，当曝气量为100L/h 时，两 者达到最大，曝气量从20L/h 增大到100L/h 时，稳定通量和稳定截留率分别提升34%和11.6%；跨膜压力 越大，浓差极化现象越严重；当跨膜压力为0.1MPa、0.3MPa、0.5MPa 时，对应的最优曝气量分别为60L/h、 100L/h、140L/h。结合浓差极化模型，分析了气液两相流提升通量和截留率的机理，为气升式膜过滤装置 应用于低分子量生化产品的分离纯化奠定基础。 关键词：气升；纳滤；浓差极化；曝气量；过滤性能 中图分类号：TQ 028.8 文献标识码：A Study on nanofiltration of bacitracin acid aqueous by airlift membrane filtration equipment 1 1 1 1 Shi Fengqiang , He Huating , Jing Wenheng , Xing Weihong 1 ( State Key Laboratory of Materials -Oriented Chemical Engineering, Nanjing University of Technology, Nanjing 210009, Jiangsu, China) Abstract ：Nanofiltration of bacitracin acid aqueous by airlift membrane filtration equipment was performed In this paper, using TiO ceramic membrane with a pore size of 0.9nm. The effect 2 of aeration rate(Q ) and transmembrane pressure (△P) on filtration performance was investigated g systematically. The results showed that gas sparging can efficiently reduce concentration polarization. When △P=0.3MPa, the steady flux and rejection increases firstly, and then decreases with the increase of aeration rate and will reach its maximum at Q = 100L/h. When g aeration rate increases from 20L/h to 100L/h, the increase rate of the steady flux and rejection was 34% and 11.6%, respective