行星齿轮两档变速器的纯电动汽车性能仿真.PDFVIP

第40卷第3期 中国测试 Vol.40 No.3 2014年5月 CHINA MEASUREMENT TEST May，2014 doi院10.11857/j.issn.1674-5124.2014.03.033 行星齿轮两档变速器的纯电动汽车性能仿真 王天利袁 张 键袁 张宏双袁 熊金胜 （辽宁工业大学汽车与交通工程学院，辽宁 锦州 121001） 摘 要院由于电动汽车采用固定速比减速器，驱动电机很难同时满足车辆的爬坡性能和最高车速要求，因此设计开发 了行星齿轮两档变速器。利用ADVISOR软件建立行星齿轮两档变速器的纯电动汽车仿真模型，然后选择CYC_ECE_ EUDC_LOW循环工况，对纯电动汽车性能进行仿真。结果表明：行星齿轮两档变速器的纯电动汽车能够满足我国纯 电动汽车动力性要求，且电机大部分工作在高效率区域，为电动汽车的设计和参数选取提供理论依据。 ； 关键词院行星齿轮；纯电动汽车；两档变速器 ADVISOR软件；仿真 中图分类号院TH16曰U469.72曰U469.212.4曰TP391.9 文献标志码院A 文章编号院1674-5124渊2014冤03-0125-04 Simulation of electric vehicle’s performance with planetary gear two-speed transmission WANG Tian-li，ZHANG Jian，ZHANG Hong-shuang，XIONG Jin-sheng （Institute of Automotive and Transportation Engineering，Liaoning University of Technology， Jinzhou 121001，China） Abstract: Since higher request was put forward to the motor of the electric vehicle with a fixed speed ratio reducer and it is difficult to meet the performance requirements of gradeability and maximum speed，planetary gear two-speed transmission was designed and developed. By use of ADVISOR software，a simulation model of the electric vehicle is established with planetary gear two-speed transmission and selecting the CYC_ECE_EUDC_LOW cycle，and the electric vehicle’s performance was simulated. Simulation results show electric vehicles with planetary gear two-speed transmission can meet requirements for electric vehicle’s dynamic performance of the country. Furthermore，the motor can mainly work in the high efficiency region. These conclusions provide a theoretical basis for the d