利用瞬态平面热源法测量烟丝三种热物性分析-analysis of three thermophysical properties of tobacco shreds measured by transient plane heat source method.docxVIP

of testing data is poor, especially the volume heat capacity.At room temperature, thermal conductivity and volume heat capacity increase with the increasing of dry bulk density and moisture content, while thermal diffusivity decreases with the increasing of the same factors. During the process of testing temperature measurement range, thermal conductivity increase with increasing temperature before water vapor temperature, while decreasing after water vapor temperature. When reaching phase transition temperature, volume heat capacity increases fast and thermal diffusivity decreases fast.Thermal conductivity of cut tobacco at various bulk densities and moisture contents were predicted by the modified W.Jackson’s contact model, and the results agree well with the experiment values. The best advantage of this predicted model is only to test apparent density and thermal conductivity of cut tobacco at zero water content. The veracity of the needed properties could be obtained under the actual testing technology.Comparations results of thermal conductivity of various kinds cut tobacco are as follows: Before the phase transition of the moisture content in cut tobacco, the thermal conductivity of tobacco sheet is higher than that of stem, flue-cured tobacco B1F is higher than Burley C3L. The comparation results of diffusivity is same as thermal conductivity. While volume specific heat of stem is higher than that of tobacco sheet, whose volume specific heat is higher than that of burley C3L . The volume specific heat of flue-cured tobacco B1F is least. After the phase transition, the thermal conductivity of tobacco sheet is higher than that of flue-cured tobacco B1F, and that of flue-cured tobacco B1F is higher than that of burley C3L. The thermal diffusivity of tobacco sheet is highest, then in turn are stem, flue-cured tobacco B1F and burley C3L. While volume specific heat of burley C3L is highest among the four kinds of cut tobacco.Keywords: thermal properties; apparent d