数值模拟研究内、外二次风风量比对350MW W火焰锅炉炉内燃烧及NOx生成特性的影响.docVIP

中国工程热物理学会 燃烧学 学术会议论文 编号：184158 数值模拟研究内、外二次风风量比对350MW W火焰锅炉炉内燃烧及NOx生成特性的影响 李晓光，曾令艳基金项目：国家自然科学基金项目（青年科学基金项目）（ 基金项目：国家自然科学基金项目（青年科学基金项目）（项目编号；国家重点研发计划，（项目编号：2016YFC0203702） （哈尔滨工业大学，哈尔滨 150001） (Tel Email:zenglingyanhit@126.com) 摘 要 本文利用数值模拟方法研究采用多次引射分级燃烧技术的350 MW W火焰锅炉不同内、外二次风风量比（0:10、2:8、5:5、6:4和10:0）对炉内燃烧及NOx生成特性的影响。随着内、外二次风风量比由0:10增大到5:5，炉膛火焰中心上移，冷灰斗区域氧量升高，炉膛出口NOx浓度减小；随着内、外二次风风量比由5:5增大到10:0，煤粉燃尽行程变短，炉膛出口NOx浓度增大；内、外二次风风量比5:5时炉膛出口NOx排放量最低为699 mg/m3 (O2=6%)，推荐实际锅炉运行时采用此风量配比。 关键词 W火焰锅炉；多次引射分级燃烧技术；数值模拟；内、外二次风风量比 Numerical Study of the Effects of the Inner and Outer Secondary Air Ratio on the Combustion and NOx Generation Characteristics in a 350MW down-fired boiler LI Xiaoguang, ZENG Lingyan*, ZHANG Shaofeng, SONG Minghang, WANG Liang, CHEN Zhichao, LI Zhengqi (Harbin institute of technology, Harbin 150001, China) (Tel Email:zenglingyanhit@126.com) Abstract Numerical simulations were conducted to study the effects of the inner and outer secondary air ratio (0:10, 2:8, 5:5, 6:4 and 10:0) on the combustion and NOx generation characteristics of a 350 MW down-fired boiler with multiple-injection and multiple-staging combustion technology. On increasing the inner and outer secondary air ratio from 0:10 to 5:5, the flame kernel moved upwards, the O2 concentration in the hopper region were increased, and the NOx emissions were reduced. On increasing the inner and outer secondary air ratio from 5:5 to 10:0, the burnout distance of pulverized-coal was shortened and the NOx emissions were increased. The NOx emissions were the lowest (699 mg/m3 (O2=6%)) at the inner and outer secondary air ratio of 5:5, and this ratio is recommend in the actual boiler operation. Keywords down-fired boiler, multiple injection and multiple staging combustion technology, numerical simulation, the inner and outer secondary air ratio